VILLAGER S12 - 4
7200 gallons / 26,640 liters per day
Filtration and Ultraviolet Light Disinfection
Stationary Solar Powered Water Purification System for Remote Applications using water from City Water, Wells, Cisterns and Water Tanks WITH water pressure.
Cleaner and Safer Drinking Water from most any from Raw Water Sources such as Rivers, Lakes, Water Tanks and Cisterns
Aqua Sun manufactures the Villager – S12 - 4 System. This system is a wall mount system and is completely automatic that can take an existing water line that is getting its water from rivers, lakes, water tanks and cisterns and produce approx 12 gallons / 44 liters per minute x 60 minutes = 720 gallons / 2,664 liters per hour x 10 hours = 7,200 gallons / 26,640 liters in a 10 hour period. This system can run approximately 24 hours continuously without sunlight. 720 gallons per hour x 24 hrs = 17,280 gallons / 63,936 liters. This system will use a solar / battery powered 12 volt system to supply its primary power needs. Whenever the sun in shinning, the solar system will always be recharging the battery, even when the water treatment system is working. This system comes as a turn-key package. It is designed for easy installation as all of the wiring is pre wired and all that needs to be done is hang the water treatment system on the wall in a convenient location. Plumping IN and OUT of the water treatment system is easy with flexible 10 foot inlet Female Brass Garden Hose Fitting and 10 foot outlet Male Hose (NSF Approved) pre-plumbed into system. The Controller Panel will need to be located with-in 3 ft of the Water Treatment System preferably in between the 2 systems. The Battery Wire is prewired and will need to have the positive and negative wires connected to the Battery. The water tubing between the 2 systems is Flexible Female Hose Brass Fittings for easy installation. Mount the Solar Panel in a sunny location and within 25 feet of the system in a convenient sunny location. Attach the solar wires to the panel that are already prewired into the control box on the side of the solar panel. Install filters and UV Lamp. Plug the UV Control Box and the Lamp Out UV Circuit Valve into the Control Panel Wire. Set the 24 hour Programmable Timer to run for approx 10 hours per day and the system is ready for operation. It is simple and easy to install the Villager S12-4 Solar / Battery Powered Water Purification Systems.
This Villager S12-4 / Solar Battery / 12-volt Powered Water Purification Systems requires a minimum of 20 psi of water pressure to push the water through a Washable / Reusable Sediment Filter which removes large particles, sticks and leaves and then through Sediment Filter to remove sand and sediment. The water is then pushed through a Carbon Block Polishing Filter that has the capabilities of removing Giardia and Cryptosporidium Cysts, Entamoeba and Toxoplasma Cysts, Schistosomiasis, Herbicides, Pesticides, Trihalomethanes (THMs), certain Volatile Organic Chemicals (VOCs), Chlorine and Chlorine By-Products, Sediment, Bad Taste, Odors, Color, Smell, and many other Harmful Chemicals and Contaminants down to a 0.5 micron. The polished filtered water is then channeled past an Ultraviolet Light Disinfecting Process that has the ability to kill Bacteria, Viruses, Typhoid Fever, Coliform, Dysentery, Cholera, Infectious Jaundice, Hepatitis and Influenza Virus, E-coli, Enteric Fever and many other unwanted microorganisms to a 99.999% purity.
The above filters can be substituted and changed out with Lead, Mercury, Arsenic or Fluoride Reduction Filters to meet most any water quality problems.
We can ship our systems to almost anywhere in the world
Shipping sizes and weights for this system.
Without Replacement Parts Kit;
2 boxes 36”x 22” x 13 @ 25 lbs.
1 box 26” x 14” x 12” @ 20 lbs.
1 box 3” x 50” x 24” @ 25 lbs.
With Replacement Parts Kit; add 2 box 24” x 14” x 14” long @ 20 Lbs ea
This does not include battery due to weight and shipping hassles, Purchase in Country. We can send requirement specifications.
We ship individually, pallets or ocean containers.
This System is approved for air shipments inside and outside the continental United States.
All water contact components carry a NSF Approval Rating and the ultraviolet light carries a Certificate of Analysis.
This system comes in 4 different models: With and Without water pressure.
Villager S8-3: 4,800 gallons / 1,776 liters in a 10 hours. This system is for areas WITH water pressure, minimum of 20-30 PSI water pressure, maximum 65 psi., no electrical power and water coming from most any from City Water, Wells, Cisterns and Water Tanks. We can design for your needs.
Villager S8-4: 4,800 gallons / 1,776 liters in a 10 hours. This system is for areas WITH water pressure, minimum of 20-30 PSI water pressure, maximum 65 psi., no electrical power and water coming from most any from Bore Holes or Tube Wells, Rivers, Lakes and Water Tanks or Fresh Water Sources. We can design for your needs.
Villager S12-3: 7,200 gallons / 26,640 liters in a 10 hours. This system is for areas WITH water pressure, minimum of 20-30 PSI water pressure, maximum 65 psi., no electrical power and water coming from most any from City Water, Wells, Cisterns and Water Tanks. We can design for your needs.
Villager S12-4: 7,200 gallons / 26,640 liters in a 10 hours. This system is for areas WITH water pressure, minimum of 20-30 PSI water pressure, maximum 65 psi., no electrical power and water coming from most any from Bore Holes or Tube Wells, Rivers, Lakes and Water Tanks or Fresh Water Sources. We can design for your needs.
Aqua Sun International is a registered DEPARTMENT OF DEFENSE CENTRAL CONTRACTOR, an approved UNITED NATIONS SUPPLIER, and a member of the AMERICAN SOLAR ENERGY SOCIETY (ASES)
The filter and UV light manufacturers are members of the Water Quality Association.
Aqua Sun International located in Minden, Nevada U.S.A. engineered and designed the Villager line of solar water purification systems starting back in 1993 and is the original / only manufacturer of this system.
All designs, product literature and names are Copyrighted 1998 – 2010 and Trademarked.
WASHABLE / REUSABLE Pre-FILTER
Removes river and lake water particles such as leaves, twigs, sediment and protects the sediment pre-filter from premature clogging. This filter is easily washed and cleaned when clogged.
APPROXIMATE FILTER LIFE EXPECTANCY depends on how dirty incoming water is or 1 year maximum.
Removes ground water sediment and protects the carbon block filter from premature clogging. Not washable.
APPROXIMATE FILTER LIFE EXPECTANCY depends on how dirty incoming water is or 1 year maximum.
0.5 micron CARBON BLOCK
Removes and reduces giardia lamblia and cryptosporidium cysts, volatile organic chemicals "VOC's" pesticides and herbicides, benzene, sediment, color, bad taste and odors such as hydrogen sulfide "rotten egg smell" and many other microorganisms down to a 0.5 micron. This Carbon Block Filter polishes the water crystal clear for refreshing good tasting water.
APPROXIMATE FILTER LIFE EXPECTANCY 150,000 gallons / 555,000 liters or one year of clean incoming water maximum.
ULTRAVIOLET DISINFECTING LAMP
Clean, safe and natural UV light rays have the ability to kill the bacteria and virus to 99.999 % purity without any harmful side effects much like chemical agents normally added to drinking water. The ultraviolet range is ideal for killing Micro-organisms such as E-coli, Coli form, Cholera, Legionnaires Disease, Hepatitis Virus, Typhoid Fever, Dysentery, Infectious Jaundice, Influenza, Enteric Fever and many other unwanted Microorganisms.
APPROXIMATE UV BULB LIFE EXPECTANCY 9000 hours, or approx 2 Years.
Turn-Key Systems, Built-in Flexibility
Easy Set-Up, Instant Water Production
12 gallons (44 liters) per minute approx.
720 gallons (2,664 liters) per hour approx.
7,200 + gallons (26.640 liters) per 10 hour day approx.
Water Source from Rivers, Lakes or Water Tanks
Pre–Plumbing and Pre-Wiring installed / connected
0.5 micron Carbon Block Filtration
Ultraviolet Light (UV) Water Disinfection System
12- volt Photovoltaic Solar Panel / Battery Powered
Control Panel: 12" tall x 9" wide x 7 deep. 15 lbs.
Solar Panel: 47" L x 21" W x 2" D x 20 lbs.
Battery: 12 volt - 13"L x 7"W x 10"D x 75 lbs.
Battery / System Running Time = 10+ hrs max.
Battery Charge Storage Life = 1+ Year
10 ft Inlet and Outlet flexible hose connections
Rated Water Pressure: 20 PSI minimum / 65 PSI maximum.
Ultraviolet Lamp Output: 16,000 microwatt seconds per centimeter squared and carries a Certificate of Analysis.
NSF and FDA APPROVED on filtration and water contact components.
Size: Filters Housings and Mounting Bracket, 30" long x 16 wide x 9" deep, 2 pcs
Size: Control Panel, 28" long x 9" wide x 7" deep, 15 Lbs.
Output Watts: Ultraviolet Light only; 22 Watts / 1.89 amps per hour
Weight Empty: approx. 80 lbs. Shipping Weight Not including Battery. Battery 75 lbs.
Inlet Connection: ¾ “Female Standard Hose Threaded Port / Swivel. 10 feet long
Outlet Connections: ¾ “Male Standard Hose Threaded Ports. 10 feet long
Rated Water Pressure; 20 PSI minimum / 65 PSI maximum
Ultraviolet Lamp Output: 16,000 microwatt seconds per centimeter squared and carries a Certificate of Analysis
Hoses, electrical cords and all misc. fittings included with system
NSF and FDA APPROVED on filtration and water contact components
Filter and UV Replacement Parts Filter Kits at a discounted available
Options (extra fees apply):
U.S. Voltage to 12 volt: 120 volt to 12 volt electrical power converter. $300.00
International Voltage to 12 volt: 220 volt 50 Hz. Uses a 220 volt 50 Hz to a 120 volt Power Step Down Transformer then the above 120 volt to 12 volt converter. $300.00
Lamp Out Circuit: Different UV System with Solenoid Valve, will not operate all water flow if UV light is not ON. $500.00
Controller / Battery Box Stand: Thief Protection with cabinet and battery box locks 48" tall x 16" wide x 12” deep. 25 lbs without Battery. $650.00
Chlorinator Pump: This pump injects a predetermined measured amount of chlorine into the water for a residual as the water travels to the outlet supply line. $1,500.00
Non Profit and Distributor Pricing available.
For pricing, more information, or to place an order,
call us at (775) 783-8566
Or click here for other ways to contact us
Here are some things people have said about the Villager S12-4
To: Aqua Sun International
La Bomba in Honduras
Sorry it took me so long to get back with you. The system is working great!
Once we were on site, we had water flowing in a couple of hours. It would have been sooner but we built a little roof over it. Take a look at the attached photos.
We mounted the system to a sheet of plywood that we attached to a concrete wall. The concrete wall used to be a cradle for some fuel tanks. You can see a well pump in one of the photos. This is a very shallow well (20 ft. deep) and has polluted water. Later, we set up a PVC pipe so that the people can pump out of the well into a couple of barrels that supply raw water to the system.
Thanks to your Villager System the village of La Bomba in Honduras, now has a source of pure water.
Thanks for all our your help. We hope to work with you in the future.
Jay Quattlebaum Washington Medical /Dental/Construction
Overseas Mission Washington Missouri
To: Aqua Sun International
To: Greg Hanson
Subject: Villager System in Ghana W. Africa
I hope you are well. I just wanted to drop you a line to let you know the status of your system.
I finally commissioned the system in March 2002! and it has been running for 3 months. To be frank with you it is the best piece of equipment in my house.
My whole family feels safe in terms of water both for bathing and drinking. My brother came down from England with his 4 month old baby and was happy to give her drinking water straight from the tap. He is a 50 year old father and generally disinfects large chunks of the planet before his daughter arrives there!
Last week I changed one of the silt filters and it was filthy on the outside, I cut it open as an experiment and found the centre to be still very clean, so I am hooked.
Thanks very much.
Department of Defense The US ARMY begins "Operation Aqua Sun" with the Outpost S
United Nations Aqua Sun is approved as a United Nations Supplier
World Vision News Aqua Sun assists World Vision with the 2007 floods in Bolivia
MSNBC News Aqua Sun colleague Leon McLaughlin was featured in an MSNBC news story about his time in Bolivia with the Aqua Sun systems.